$49 / month O.A.C Including Install
$49 / month O.A.C Including Install

Quick Troubleshooting Guide for Furnace Issues

24 / 7 Emergency Service Available. Call Us Now: 1.844.894.6832


[BACK]
Quick Troubleshooting Guide for Furnace Issues

Posted On: December 9, 2024

Quick Troubleshooting Guide for Furnace Issues

A malfunctioning furnace can be a major inconvenience, especially during colder months. Below is a simple guide to help identify and potentially resolve common furnace issues before calling a professional.



1. Furnace Won’t Turn On

  • Check the Thermostat: Ensure it’s set to “Heat” and the temperature is set higher than the room temperature.
  • Power Supply: Verify that the furnace is receiving power. Check the circuit breaker and reset it if necessary.
  • Pilot Light or Ignition System: For older models, ensure the pilot light is lit. Modern furnaces might have electronic ignitions, which may need resetting.

2. Weak or No Airflow

  • Check the Air Filter: A clogged filter can restrict airflow. Replace the filter if it’s dirty.
  • Inspect the Blower Motor: Ensure the blower motor is functioning. Listen for unusual sounds or inspect the belt for damage.
  • Blocked Vents: Make sure all supply and return vents are open and unobstructed.

3. Furnace Blowing Cold Air

  • Thermostat Setting: Double-check that the thermostat is set to “Auto” and not “Fan.”
  • Pilot Light or Ignition Issue: If the pilot light is out, relight it following the manufacturer’s instructions.
  • Gas Supply: Ensure the gas valve is open and the supply is uninterrupted.

4. Frequent Cycling (Turns On and Off Repeatedly)

  • Dirty Air Filter: Replace if clogged.
  • Thermostat Placement: Ensure the thermostat is not placed near a heat source, as this can cause incorrect temperature readings.
  • Overheating: A clogged filter or dirty blower wheel might cause the system to overheat and shut down as a safety precaution.

5. Strange Noises

  • Rattling: Check for loose panels or screws and tighten them.
  • Squealing: This might indicate a worn-out blower belt or motor bearings needing lubrication or replacement.
  • Banging: Could signal a delayed ignition or ductwork expansion; consider professional inspection.

6. Furnace Leaking Water

  • Condensate Line Blockage: Ensure the condensate drain line is clear and unclog it if necessary.
  • Clogged Drain Pan: Check and empty the drain pan if it’s full.
  • Condensing Furnace Issues: Inspect the exhaust vent or condensate pump for malfunctions.

7. Furnace Not Producing Enough Heat

  • Thermostat Calibration: Ensure the thermostat is accurate and functioning correctly.
  • Dirty Burner or Heat Exchanger: Clean these components carefully or schedule professional maintenance.
  • Ductwork Issues: Check for leaks or blockages in the duct system.

When to Call a Professional

If troubleshooting doesn’t resolve the issue or if you notice signs of a more serious problem (e.g., gas smells, persistent leaks, or electrical issues), contact a certified HVAC technician immediately.


Regular maintenance and timely filter replacements can prevent many of these common issues!



[BACK]

See What Our Customers Are Saying:

by Private User on Twintech Heating and Cooling

Twintech promptly responded to request for quotation. They were thorough and helpful in explaining options. The quote was very competitive. Installation of new furnace was very professionally completed. Excellent work.

by Rita, Scarborough on Twintech Heating and Cooling

When our old oil furnace finally broke down we decided it was time to finally convert to natural gas and finally install central air conditioning at the same time. Knowing it was going to be a significant investment for us, we wanted to make the right choice. Twintech came highly recommended by a friend and we were not disappointed. From the first contact with the salesperson, until the final touches on the installation, we were so pleased with their service. Everyone from the company was so friendly, efficient and a pleasure to deal with. Best of all, the cost was very competitive. We would certainly recommend Twintech to anyone requiring HVAC work in their home.

by Bob S, Pickering on Twintech Heating and Cooling

Mitch from Twintech came out for our annual furnace inspection. We found him to be friendly, conscientious & he left the work area clean. We were also very impressed with the thoroughness of the job he did. This is the 2nd job we’ve had Twintech do for us & have been very happy with the results for each. We highly recommend this company. Thank you, Mitch, Dave & Greg.

by Brent L on Twintech Heating and Cooling

Work was done on schedule, professionally, according to quote and with minimal inconvenience to building users. Very happy with the end result. The only area for improvement from my experience - need more timely quoting process.

by Karen on Twintech Heating and Cooling

The team was great! Very knowledgeable, professional and extremely helpful. A few days after install the unit didn’t seem to be working, user error, but within minutes of contacting them..on a Saturday.. a tech was on the phone troubleshooting with us. I highly recommend Twintech for your cooling or heating needs. They stand by their products and a pleasure to deal with.

by Rob on Twintech Heating and Cooling

During the hottest week in the summer our old A/C decided to call it quits. I called Twintech Heating & Cooling after receiving a referral from a family member; came highly rated for being an honest, family-run business, who appreciates their customers. Dave was able to accommodate my hectic schedule and book a late evening appointment to walk through the specifics. Greg and Mitch arrived exactly on time a few days later, were very polite and friendly, and within a couple of hours had a new unit up and running. I also received a follow-up call to ensure we were happy with the Amana.

by Linda Robinson on Twintech Heating and Cooling

They were on time and very professional. I'm so glad I decided to go with Twintech, thanks!

by Famcam1953 on Twintech Heating and Cooling

Timely and appreciated - this was during the hottest days this year when our Air and Furnace way.
Efficient. Professional. No BS or overselling. What was promised, was delivered at a cost-effective price point.
Down to earth.

by DG Sellers on Twintech Heating and Cooling

Professionally done and took care to cover all entry floors to the house for the installers to remove the old furnace and install a new furnace.
I also made recommendations of the tankless water heater that we had installed and items to address. We did not know they also installed tankless water heaters.

by Bill, Pickering on Twintech Heating and Cooling

Price was not the cheapest nor the most expensive of my quotes. It's the quality of the installation that makes for a good AC system. The twins' knowledge & professionalism was evident in the small details:
Very clean work. Greg made sure that the refrigerant level & temperature were correct. They reinstall the insulation & vapor barrier around the wall. The outside electrical cords were secured to the wall. Proud to support this local company. Thank you.

Related Links:
oshawa gas furnace problems, ac service call, pickering hvac prices, local ac services, ajax furnace inspection, ac repair services, whitby furnace replacement, furnace repairs pickering, oshawa hvac furnaces, central ac service, ac unit maintenance, pickering gas furnace problems, ac installation near me, ajax hvac repair, hvac repairs, ac contractors, ac repair and service, whitby furnaces, residential furnace, residential ac repair, pickering hvac furnace, pickering furnace service, pickering furnaces, oshawa furnace inspection, oshawa furnaces, nearby ac repair,


See What Our Customers Are Saying:

by Robert Rogers on Twintech Heating and Cooling

Very pleased with the professional service that TwinTech Heating and Cooling provided in replacing my furnace. I got several quotes from different service providers. Their price was excellent and they explained the features very well. We are very glad we went with TwinTech and highly recommend their services.

by Robert Mizuno on Twintech Heating and Cooling

We were new homeowners in need of a second opinion. TwinTech Heating & Cooling were Amazing and professional. Very knowledgeable and great service all around. Recommend to anyone looking for honest and reliable services. Treated with respect and care. Thank you Greg, Mitch and Bob!

by Ruth on Twintech Heating and Cooling

TwinTech is an excellent and honest company! I called them for a second opinion after being told by another company that I needed to replace my furnace. Turns out this was not the case at all! I did not need a new furnace. TwinTech did not push to make an unnecessary sale and saved me from a huge expense. Bob and Mitch were extremely professional and above all honest! I definitely recommend TwinTech!

by Anna Chin on Twintech Heating and Cooling

Amazing experience with TwinTech Heating & Cooling! Their team was professional, knowledgeable, and efficient from start to finish. They installed my new furnace quickly and left everything spotless. The technicians took the time to explain everything and made sure I was comfortable with the system before they left. Great customer service and fair pricing. I highly recommend them for anyone needing HVAC services!

by Connor Agnew on Twintech Heating and Cooling

Great experience all around. Bob was sharp and easy to talk to, and Greg handled the installation perfectly. Would hire them again in a heartbeat.

What You Need to Know Before Buying a Heat Pump

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - November 13, 2023

Buying a heat pump is a significant decision that can impact your home's comfort and energy efficiency. Here are key factors to consider before purchasing a heat pump: Climate and Region: Heat pumps are most effective in moderate

Read More

My Furnace is Cycling Frequently

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - March 18, 2025

If your furnace is cycling on and off more frequently than usual (called short cycling), it’s usually a sign that something’s wrong. Let’s troubleshoot some common causes: Dirty Air Filter A clogged filter restricts airfl

Read More

The Importance of Furnace Cleaning

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - February 27, 2025

Furnace cleaning is essential for maintaining a safe, efficient, and long-lasting heating system. Here’s why it’s important: 1. Improves Energy Efficiency A clean furnace runs more efficiently, using less energy to heat your home. D

Read More

Air Conditioner Coolant Explosion

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - July 10, 2023

I just spent several hours taking my AC apart to clean it and I put it back together and it was working fine for an hour but then it blew up and flew back into my room ejecting coolant everywhere. Googling this situation seems to give me no result

Read More