$49 / month O.A.C Including Install
$49 / month O.A.C Including Install

Furnace Pilot Light Malfunctioning

24 / 7 Emergency Service Available. Call Us Now: 1.844.894.6832


[BACK]
Furnace Pilot Light Malfunctioning

Posted On: December 29, 2024

Furnace Pilot Light Malfunctioning

If your furnace pilot light is malfunctioning, it can prevent your heating system from working effectively. Here’s a detailed guide to identify and resolve common pilot light issues:


1. Understand the Problem

The pilot light is a small flame that ignites the burners in your furnace. If it’s malfunctioning or won’t stay lit, your furnace may not generate heat.



2. Common Causes

  1. Dirty Pilot Orifice
    Dust, debris, or soot can clog the pilot orifice, reducing or extinguishing the flame.


  2. Thermocouple Issues
    The thermocouple is a safety device that shuts off the gas supply if the pilot light goes out. If it’s faulty or misaligned, the pilot may not stay lit.


  3. Drafts or Airflow Problems
    Strong drafts near the furnace can blow out the pilot light.


  4. Gas Supply Issues
    Insufficient gas pressure or a gas valve issue can prevent the pilot from staying lit.


  5. Malfunctioning Gas Control Valve
    If the gas valve is faulty, it may not release enough gas for the pilot light to ignite.



3. Troubleshooting Steps

a. Inspect the Pilot Light

  • Check if the flame is burning. A healthy pilot light should be steady and blue. If it’s yellow or flickering, it may indicate a problem with the gas mixture or airflow.

b. Relight the Pilot Light

  1. Turn off the furnace and wait for gas to dissipate (5-10 minutes).
  2. Locate the pilot light assembly and turn the gas control knob to "Pilot."
  3. Hold down the reset button and use a long lighter to ignite the flame.
  4. Release the button slowly after 30-60 seconds.

c. Clean the Pilot Orifice

  • Turn off the gas supply and use a needle or compressed air to remove debris from the pilot orifice.

d. Test the Thermocouple

  • Ensure the thermocouple is in direct contact with the flame. If misaligned, adjust its position.
  • If it’s worn out, replace the thermocouple.

e. Check for Drafts

  • Seal any openings near the furnace to prevent drafts from blowing out the flame.

f. Inspect Gas Supply

  • Verify that the gas valve is open and gas is flowing properly. Consult a professional if there’s a suspected gas pressure issue.

4. When to Call a Professional

  • If the pilot light still won’t stay lit after troubleshooting.
  • You suspect a gas leak or faulty gas valve.
  • There’s a persistent yellow or weak flame.

5. Maintenance Tips

  1. Schedule annual furnace maintenance.
  2. Keep the pilot light assembly clean.
  3. Regularly check for drafts and airflow issues.
  4. Monitor your furnace’s performance during the heating season.

Addressing a malfunctioning pilot light promptly ensures a warm and safe home. If in doubt, always consult a licensed HVAC technician.



[BACK]

See What Our Customers Are Saying:

by Private User on Twintech Heating and Cooling

Twintech promptly responded to request for quotation. They were thorough and helpful in explaining options. The quote was very competitive. Installation of new furnace was very professionally completed. Excellent work.

by Rita, Scarborough on Twintech Heating and Cooling

When our old oil furnace finally broke down we decided it was time to finally convert to natural gas and finally install central air conditioning at the same time. Knowing it was going to be a significant investment for us, we wanted to make the right choice. Twintech came highly recommended by a friend and we were not disappointed. From the first contact with the salesperson, until the final touches on the installation, we were so pleased with their service. Everyone from the company was so friendly, efficient and a pleasure to deal with. Best of all, the cost was very competitive. We would certainly recommend Twintech to anyone requiring HVAC work in their home.

by Bob S, Pickering on Twintech Heating and Cooling

Mitch from Twintech came out for our annual furnace inspection. We found him to be friendly, conscientious & he left the work area clean. We were also very impressed with the thoroughness of the job he did. This is the 2nd job we’ve had Twintech do for us & have been very happy with the results for each. We highly recommend this company. Thank you, Mitch, Dave & Greg.

by Brent L on Twintech Heating and Cooling

Work was done on schedule, professionally, according to quote and with minimal inconvenience to building users. Very happy with the end result. The only area for improvement from my experience - need more timely quoting process.

by Karen on Twintech Heating and Cooling

The team was great! Very knowledgeable, professional and extremely helpful. A few days after install the unit didn’t seem to be working, user error, but within minutes of contacting them..on a Saturday.. a tech was on the phone troubleshooting with us. I highly recommend Twintech for your cooling or heating needs. They stand by their products and a pleasure to deal with.

by Rob on Twintech Heating and Cooling

During the hottest week in the summer our old A/C decided to call it quits. I called Twintech Heating & Cooling after receiving a referral from a family member; came highly rated for being an honest, family-run business, who appreciates their customers. Dave was able to accommodate my hectic schedule and book a late evening appointment to walk through the specifics. Greg and Mitch arrived exactly on time a few days later, were very polite and friendly, and within a couple of hours had a new unit up and running. I also received a follow-up call to ensure we were happy with the Amana.

by Linda Robinson on Twintech Heating and Cooling

They were on time and very professional. I'm so glad I decided to go with Twintech, thanks!

by Famcam1953 on Twintech Heating and Cooling

Timely and appreciated - this was during the hottest days this year when our Air and Furnace way.
Efficient. Professional. No BS or overselling. What was promised, was delivered at a cost-effective price point.
Down to earth.

by DG Sellers on Twintech Heating and Cooling

Professionally done and took care to cover all entry floors to the house for the installers to remove the old furnace and install a new furnace.
I also made recommendations of the tankless water heater that we had installed and items to address. We did not know they also installed tankless water heaters.

by Bill, Pickering on Twintech Heating and Cooling

Price was not the cheapest nor the most expensive of my quotes. It's the quality of the installation that makes for a good AC system. The twins' knowledge & professionalism was evident in the small details:
Very clean work. Greg made sure that the refrigerant level & temperature were correct. They reinstall the insulation & vapor barrier around the wall. The outside electrical cords were secured to the wall. Proud to support this local company. Thank you.

Related Links:
oshawa gas furnace problems, ajax furnace inspection, whitby furnace replacement, furnace repairs pickering, oshawa hvac furnaces, pickering gas furnace problems, whitby furnaces, residential furnace, pickering hvac furnace, pickering furnace service, pickering furnaces, oshawa furnace inspection, oshawa furnaces, gas furnace problems, furnace services oshawa, furnace maintenance near me, furnace repair ajax, furnace repair pickering, furnace repair oshawa, furnace replacement, furnace repairs, furnace repair, furnace installations ajax, furnace installations pickering, furnace installations oshawa, furnace inspection,


See What Our Customers Are Saying:

by Robert Rogers on Twintech Heating and Cooling

Very pleased with the professional service that TwinTech Heating and Cooling provided in replacing my furnace. I got several quotes from different service providers. Their price was excellent and they explained the features very well. We are very glad we went with TwinTech and highly recommend their services.

by Robert Mizuno on Twintech Heating and Cooling

We were new homeowners in need of a second opinion. TwinTech Heating & Cooling were Amazing and professional. Very knowledgeable and great service all around. Recommend to anyone looking for honest and reliable services. Treated with respect and care. Thank you Greg, Mitch and Bob!

by Ruth on Twintech Heating and Cooling

TwinTech is an excellent and honest company! I called them for a second opinion after being told by another company that I needed to replace my furnace. Turns out this was not the case at all! I did not need a new furnace. TwinTech did not push to make an unnecessary sale and saved me from a huge expense. Bob and Mitch were extremely professional and above all honest! I definitely recommend TwinTech!

by Anna Chin on Twintech Heating and Cooling

Amazing experience with TwinTech Heating & Cooling! Their team was professional, knowledgeable, and efficient from start to finish. They installed my new furnace quickly and left everything spotless. The technicians took the time to explain everything and made sure I was comfortable with the system before they left. Great customer service and fair pricing. I highly recommend them for anyone needing HVAC services!

by Connor Agnew on Twintech Heating and Cooling

Great experience all around. Bob was sharp and easy to talk to, and Greg handled the installation perfectly. Would hire them again in a heartbeat.

Why is My Furnace Not Heating Properly?

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - October 29, 2023

However, here are some common reasons why a furnace may not be heating properly: Thermostat Settings: Check if the thermostat is set to the desired temperature. Ensure that the thermostat is set to the "Heat" mode.

Read More

Air Ducts: To Clean or Not to Clean

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - October 13, 2020

Duct cleaning has been quite popular in the past few years with commercial cleaning services happening everywhere. But really, is this service worth the hype or is it just a really good scamIn this post, we aim to provide you with information that c

Read More

Reducing Energy Costs on My AC

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - March 31, 2024

Reducing energy costs on your air conditioning (AC) system can help save money and reduce your carbon footprint. Here are several tips to achieve this: Use a Programmable Thermostat: Set your thermostat to higher temperatures when you're

Read More

Portable AC not cooling at all

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - September 8, 2023

It's frustrating when your portable AC unit doesn't seem to be cooling your room effectively. There are several steps you can take to improve its cooling performance: Proper Installation: Ensure that the portable AC unit is installed co

Read More