$49 / month O.A.C Including Install
$49 / month O.A.C Including Install

Common Furnace Problems and How to Fix Them

24 / 7 Emergency Service Available. Call Us Now: 1.844.894.6832


[BACK]
Common Furnace Problems and How to Fix Them

Posted On: December 26, 2024

Common Furnace Problems and How to Fix Them

Here’s a comprehensive guide to common furnace problems and how to fix them:



1. Furnace Won’t Turn On

Possible Causes:


  • Thermostat is not set correctly.
  • Power issue (tripped circuit breaker or blown fuse).
  • Pilot light is out (for older models).

Fix:


  • Check the thermostat and set it to “heat” mode.
  • Ensure the thermostat is set higher than the current room temperature.
  • Check your home’s circuit breaker panel and reset any tripped breakers.
  • Relight the pilot light if applicable, following the manufacturer’s instructions.

2. Furnace Is Not Producing Enough Heat

Possible Causes:


  • Dirty air filter.
  • Blocked vents or registers.
  • Malfunctioning blower motor or heat exchanger.

Fix:


  • Replace or clean the air filter to improve airflow.
  • Ensure all vents and registers are open and unobstructed.
  • Call a professional to inspect the blower motor or heat exchanger if cleaning doesn’t resolve the issue.

3. Furnace Blowing Cold Air

Possible Causes:


  • Incorrect thermostat settings.
  • Pilot light is out.
  • Clogged condensate drain in high-efficiency furnaces.

Fix:


  • Verify that the thermostat is set to “heat” mode.
  • Relight the pilot light if necessary.
  • Clear any blockages in the condensate drain or contact a technician.

4. Frequent Cycling (Turning On and Off)

Possible Causes:


  • Dirty air filter.
  • Improper thermostat placement.
  • Oversized or undersized furnace.

Fix:


  • Replace the air filter.
  • Make sure the thermostat is not near heat sources like direct sunlight or appliances.
  • Consult an HVAC professional to determine if your furnace is the right size for your home.

5. Furnace Is Making Strange Noises

Possible Causes:


  • Rattling: Loose panels or components.
  • Squealing: Worn blower belt or motor bearings.
  • Banging: Delayed ignition or expanding ductwork.

Fix:


  • Tighten any loose panels or screws.
  • Replace or lubricate the blower belt and bearings.
  • Have a professional inspect the ignition system if you hear banging sounds.

6. Pilot Light Won’t Stay Lit

Possible Causes:


  • Dirty pilot orifice.
  • Faulty thermocouple.
  • Draft in the furnace area.

Fix:


  • Clean the pilot orifice with a small brush.
  • Replace the thermocouple if it’s not functioning.
  • Check for drafts and seal any gaps around the furnace.

7. Furnace Leaks Water

Possible Causes:


  • Clogged or damaged condensate drain.
  • Broken or clogged humidifier.

Fix:


  • Unclog or replace the condensate drain.
  • Inspect the humidifier for blockages or leaks and repair as needed.

8. High Energy Bills

Possible Causes:


  • Poor furnace efficiency.
  • Dirty air filter.
  • Leaky ducts.

Fix:


  • Schedule a professional furnace tune-up to improve efficiency.
  • Replace air filters regularly.
  • Seal any duct leaks with foil tape or mastic sealant.

When to Call a Professional

While some furnace problems can be fixed with simple troubleshooting, others require professional expertise. If your furnace is still not functioning properly after attempting these fixes, or if you suspect a dangerous issue such as a gas leak or cracked heat exchanger, contact an HVAC technician immediately.



[BACK]

See What Our Customers Are Saying:

by Robert Rogers on Twintech Heating and Cooling

Very pleased with the professional service that TwinTech Heating and Cooling provided in replacing my furnace. I got several quotes from different service providers. Their price was excellent and they explained the features very well. We are very glad we went with TwinTech and highly recommend their services.

by Robert Mizuno on Twintech Heating and Cooling

We were new homeowners in need of a second opinion. TwinTech Heating & Cooling were Amazing and professional. Very knowledgeable and great service all around. Recommend to anyone looking for honest and reliable services. Treated with respect and care. Thank you Greg, Mitch and Bob!

by Ruth on Twintech Heating and Cooling

TwinTech is an excellent and honest company! I called them for a second opinion after being told by another company that I needed to replace my furnace. Turns out this was not the case at all! I did not need a new furnace. TwinTech did not push to make an unnecessary sale and saved me from a huge expense. Bob and Mitch were extremely professional and above all honest! I definitely recommend TwinTech!

by Anna Chin on Twintech Heating and Cooling

Amazing experience with TwinTech Heating & Cooling! Their team was professional, knowledgeable, and efficient from start to finish. They installed my new furnace quickly and left everything spotless. The technicians took the time to explain everything and made sure I was comfortable with the system before they left. Great customer service and fair pricing. I highly recommend them for anyone needing HVAC services!

by Connor Agnew on Twintech Heating and Cooling

Great experience all around. Bob was sharp and easy to talk to, and Greg handled the installation perfectly. Would hire them again in a heartbeat.

by Trevor Owens on Twintech Heating and Cooling

I returned from vacation to find my AC unit on the Fritz. After calling way too many places I connected with TwinTech. I’ve used the company in the past for my furnace so I was happy when I recognized Greg at my front door. He’s great and the service is always top notch. I’d highly recommend using twintech for honest, superior service in the Durham region. Thanks!

by Nicole Alain on Twintech Heating and Cooling

I called Twin Tech when my air conditioning stopped working. Greg came over to diagnose the issue - the same day. He was able to diagnose the issue and resolve it quite quickly. Although it was a quick fix, Greg was very thorough in explaining the issue and provided great advice. Not to mention, I felt very comfortable having Greg in my home - which I consider very important when hiring a service provider. Twin Tech will be my go-to from now on. Thank you!!

by Courtney Parkes on Twintech Heating and Cooling

Just hired TwinTech Heating & Cooling to do an A/C Unit removal & reinstall to allow for landscaping access on the side of my house, and they were wonderful!
Bob, Greg & Mitch make a great team! Quick appointment times, super knowledgeable, expert troubleshooting capabilities & very customer service oriented.
I would highly recommend them for all of your HVAC needs! Great job guys!!

by Jacqueline Graham on Twintech Heating and Cooling

Twintech Heating & Cooling installed my furnace in 2022 and in fall of 2023 installed my Panasonic Heat Pump. Greg and Mitch did a great job. Helped me through the rebate process. Super happy with the Heat Pump. Only used my furnace 5 times this winter. Energy bills lower, carbon emissions lower.Thank you Twintech. I recommend highly!

by Bill Grainger on Twintech Heating and Cooling

Just had a new furnace installed by Twintech. I can’t express how great these guys are at what they do. From the sales to installation they were professional all the way. Very reasonable pricing and courteous during the installation and willing to answer any questions I had. Highly recommended !!!

Related Links:
oshawa gas furnace problems, ac service call, pickering hvac prices, local ac services, ajax furnace inspection, ac repair services, whitby furnace replacement, furnace repairs pickering, oshawa hvac furnaces, central ac service, ac unit maintenance, pickering gas furnace problems, ac installation near me, ajax hvac repair, hvac repairs, ac contractors, ac repair and service, whitby furnaces, residential furnace, residential ac repair, pickering hvac furnace, pickering furnace service, pickering furnaces, oshawa furnace inspection, oshawa furnaces, nearby ac repair,


See What Our Customers Are Saying:

by Robert Rogers on Twintech Heating and Cooling

Very pleased with the professional service that TwinTech Heating and Cooling provided in replacing my furnace. I got several quotes from different service providers. Their price was excellent and they explained the features very well. We are very glad we went with TwinTech and highly recommend their services.

by Robert Mizuno on Twintech Heating and Cooling

We were new homeowners in need of a second opinion. TwinTech Heating & Cooling were Amazing and professional. Very knowledgeable and great service all around. Recommend to anyone looking for honest and reliable services. Treated with respect and care. Thank you Greg, Mitch and Bob!

by Ruth on Twintech Heating and Cooling

TwinTech is an excellent and honest company! I called them for a second opinion after being told by another company that I needed to replace my furnace. Turns out this was not the case at all! I did not need a new furnace. TwinTech did not push to make an unnecessary sale and saved me from a huge expense. Bob and Mitch were extremely professional and above all honest! I definitely recommend TwinTech!

by Anna Chin on Twintech Heating and Cooling

Amazing experience with TwinTech Heating & Cooling! Their team was professional, knowledgeable, and efficient from start to finish. They installed my new furnace quickly and left everything spotless. The technicians took the time to explain everything and made sure I was comfortable with the system before they left. Great customer service and fair pricing. I highly recommend them for anyone needing HVAC services!

by Connor Agnew on Twintech Heating and Cooling

Great experience all around. Bob was sharp and easy to talk to, and Greg handled the installation perfectly. Would hire them again in a heartbeat.

My Furnace Does Not Produce Enough Heat

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - December 29, 2024

If your furnace is not producing enough heat, there could be several potential issues causing the problem. Here’s a step-by-step guide to help you identify and resolve the issue: 1. Check the Thermostat Settings Ensure it's set t

Read More

Why Get a Panasonic Heat Pump?

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - September 15, 2023

Choosing a Panasonic heat pump can offer several benefits, as Panasonic is a well-known brand with a reputation for producing high-quality appliances. Here are some reasons why you might consider getting a Panasonic heat pump: Energy Efficie

Read More

Does My AC Accommodate My Home Size?

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - March 11, 2024

To determine if your air conditioning (AC) system adequately accommodates the size of your home, you'll need to consider several factors: Square footage of your home: Calculate the square footage of your home, including all living spaces

Read More

The Importance of Regular HVAC Maintenance

  • SUBMITTED BY:
  • TWINTECH HEATING & COOLING
  • - April 13, 2022

Seasons change all-year round, but there is one thing that should always be constant in your home: the desired temperature you want your home to have. This should not be difficult to achieve. You might think that foregoing regular maintenance might s

Read More